| Author |
Message |
|
Roger V
Firing on two.
Joined: March 21st, 2013, 12:04 am
Posts: 1581
Location: Exeter, Devon
|
 Electric fuel pump Hi there I've bought an electric fuel pump as my mechanical was giving symptoms of being a bit weak at higher revs. Wondering what I need to do regarding the old pump! Curious as to what would happen if I connected them in series ( replacing the metal connector) for simplicity. Would this double the pressure. Physics not my strong point, though I have got the hang of the wheel and the lever.  Any thoughts appreciated. Roger V
_________________
If you can't fix it with a hammer, it's probably electrical (or, an electric fuel pump!) ....
|
| November 23rd, 2016, 5:58 pm |
|
|
|
Sean
Firing on two.
Joined: April 22nd, 2009, 11:06 pm
Posts: 3684
Location: Ecosse
|
Re: Electric fuel pump youd have to remove the pump take the pushrod out and either blank off the area with a plate or just refit the old pump
Bypass the pump, why would you want to double up the pumps?
you need to think how your wiring it you don't want the pump running constantly and ideally cuts out in the case of an accident
_________________
Kissing the Lash
"Any advice of a technical nature is given on the understanding that I've actually done this shit, not just read about it in D*lly club mag some time ago.
|
| November 23rd, 2016, 10:58 pm |
|
|
|
Roger V
Firing on two.
Joined: March 21st, 2013, 12:04 am
Posts: 1581
Location: Exeter, Devon
|
Re: Electric fuel pump Thanks Sean I'll remove the pushrod and replace the pump. That is a sensible idea regarding stopping pumping when the engine is not running. Off the oil pressure perhaps, though I am not sure how, as when i think about it, the oil switch is on the negative side. I wonder if they did it on the Mini and Morris Minor! Cheers 
_________________
If you can't fix it with a hammer, it's probably electrical (or, an electric fuel pump!) ....
|
| November 23rd, 2016, 11:21 pm |
|
|
|
EirikJ
Firing on two.
Joined: February 17th, 2009, 8:43 pm
Posts: 567
Location: NOrWAY
|
Re: Electric fuel pump Why not replace the old mechanical one, with a new mechanical one?
Then you keep it simple and tidy.
_________________
Vennlig hilsen, Eirik
Five 2CV's, DS 21 ieh Pallas -70, DS 23 h Pallas -75, CX 25 GTi automatic -89, XM 2,0i -90
And a Heinemann Z412 -80
|
| November 24th, 2016, 12:07 am |
|
|
|
Jonathan
Firing on two.
Joined: January 1st, 2009, 7:37 pm
Posts: 4695
Location: Disunited Kingdom
|
Re: Electric fuel pump Was only chatting in work yesterday about the SU electric fuel pump on my old Morris Minor Tourer sticking at the most inopportune times. Like in lane 3 on the motorway. Small mallet was part of my tool kit. A quick smack on the body of the pump would result in the points unsticking and clicking madly to draw fuel back up from the tank. Also had a tin of WD40 to spray on the points if they continued to stick. 
_________________
1988 built (1989 F-registered) Citroën 2CV-Six
2013 (63-Plate) VW Golf SE 1.4TSI BMT DSG7
1932 Morris Minor Open Two-Seater (The £100 car).
|
| November 24th, 2016, 9:28 pm |
|
|
|
Roger V
Firing on two.
Joined: March 21st, 2013, 12:04 am
Posts: 1581
Location: Exeter, Devon
|
Re: Electric fuel pump I'll make sure I locate in a suitable place where I can hit it with mallet then.
_________________
If you can't fix it with a hammer, it's probably electrical (or, an electric fuel pump!) ....
|
| November 24th, 2016, 10:09 pm |
|
|
|
Jonathan
Firing on two.
Joined: January 1st, 2009, 7:37 pm
Posts: 4695
Location: Disunited Kingdom
|
Re: Electric fuel pump PMSL! Just noticed the little quote at the bottom of your posts. Well I've just showed an electrical fault can be cured by a hammer. 
_________________
1988 built (1989 F-registered) Citroën 2CV-Six
2013 (63-Plate) VW Golf SE 1.4TSI BMT DSG7
1932 Morris Minor Open Two-Seater (The £100 car).
|
| November 24th, 2016, 11:17 pm |
|
|
